In the introduction of how to use the automatic concrete mixer safely, we have learned some unknown problems or knowledge, but we are still unfamiliar with the industry where the mixer is located. Today, we will learn about it:

1、冬期施工时，应切实做到:开机前检查是否结冰;下班时认真排除拌筒内及供水系统内残存积水，关闭水泵开关，将控制手柄置于“停止"位置。

1. During winter construction, it is necessary to check whether there is icing before starting the machine; when off duty, carefully remove the residual water in the mixing drum and water supply system, turn off the water pump switch, and put the control handle at the "stop" position.

2、混凝土搅拌车卸料时，如发现水分蒸发，塌落度偏低不能满足用户要求时，可适当向筒内加水，然后以10-14r/min的速度旋转30转后卸料，使混凝士充分搅拌。

2. When the concrete mixer truck is discharging, if it is found that the water evaporates and the slump is too low to meet the user's requirements, water can be properly added into the cylinder, and then the concrete can be discharged after 30 rotations at the speed of 10-14 R / min, so that the concrete can be fully mixed.

3、自动混凝土搅拌机在空载运行过程中，搅拌筒不得停转以免颠时造成滚道和托轮局部磕碰，导致托轮和滚道的异常损坏。

3. In the process of no-load operation of automatic concrete mixer, the mixing drum shall not stop, so as to avoid the local collision between the roller track and the supporting roller, which may lead to the abnormal damage of the roller and raceway.

4、水箱的水量要经常加满，以备急用。水箱加水前，必须打开放气阀把箱内空气放掉;冲洗时打开气阀，冲洗完毕或者停用时应将水罐内气体放掉。

4. The water tank should always be filled up in case of emergency. Before adding water into the water tank, the air vent valve must be opened to drain the air in the tank; when the water tank is flushed, the air valve shall be opened, and the gas in the water tank shall be discharged after the flushing or shutdown.

冬季停放时，水箱和供水系统里，不得有剩余水，防止冻裂，水箱仅在供水时加压自动，混凝土自动上料搅拌车怎么使用不要带着加压水箱在公路上行驶。

When parking in winter, there should be no residual water in the water tank and water supply system to prevent frost cracking. The water tank is only pressurized automatically when supplying water. How to use the automatic concrete loading mixer safely? Do not drive on the road with the pressurized water tank.

1、随车带上减水剂：减水剂是一种在维持混凝土坍落度不变的条件下，能减少拌合用水量的混凝土外加剂，随车携带，能对混凝土进行很好的调节。

1. Water reducer with vehicle: water reducer is a kind of concrete admixture which can reduce the water consumption of mixing under the condition of maintaining the concrete slump unchanged. It can adjust the concrete well when carried with the vehicle.

2、回厂检查罐内水量：每次出车任务完成回到站内的时候，检查储水罐内的水量，让水罐中的水随时处于满罐的状态，以备不时之需。

2. Return to the factory to check the water volume in the tank: when returning to the station after the completion of the vehicle dispatching task, check the water volume in the water storage tank to make the water in the water tank full at any time in case of emergency.

3、离厂前检查混凝土质量：可能会因为原料的不同，每一盘混凝土质量都会有变化。

3. Check the concrete quality before leaving the factory: the quality of each concrete plate may change due to different raw materials.

4、减少车辆行驶时间：混凝土运距一般在直径30千米范围以内，出车之前规划好路线以及车辆通行情况。

4. Reduce the driving time of vehicles: the concrete transportation distance is generally within the range of 30 km in diameter, and the route and vehicle traffic condition shall be planned before the vehicle is driven.

5、减少损失先卸料：如果遇到人为因素或者不可抗因素，导致长时间无法卸料的情况，一旦发现混凝土开始凝结，在报备负搅拌责自动上料搅拌车防止粘罐的方法人之后立刻进行卸料，以防整个罐体报废。

5. Reduce the loss and discharge first: in case of long-term failure to discharge due to human factors or irresistible factors, once the concrete starts to set, the unloading shall be carried out immediately after reporting the method person responsible for automatic feeding mixer to prevent sticking to the tank, so as to prevent the whole tank body from being scrapped.

自动混凝土搅拌机怎么使用所述的内容，是我们的小编精心为大家准备的，还记得上篇中说了什么吗？这些或许都有些不的地方，我们会在以后的文章中为大家一一说明

How to use the automatic concrete mixer safely? Our editor carefully prepared the content for you. Do you remember what was said in the last part? These may not be comprehensive, we will explain them one by one in future articles