欢迎您访问中科聚峰机械有限公司网站!
搅拌机行业持续先行者!
点击拨打服务热线:400-879-1999
您的位置: 首页 > 新闻资讯>>混凝土搅拌机的操作要符合相关内容才合适

新闻资讯

热销产品

推荐新闻

  • 安全使用规范是什么?
  • 聚峰混凝土搅拌车,您的选择!
  • 高效作业的前提:即正确使用混凝土搅拌车
  • 聚峰带你了解混凝土搅拌车的价格
  • 聚峰浅谈自上料搅拌车
  • 中科聚峰厂家告诉你如何使用小型混凝土搅拌机

全国服务热线

400-879-1999
新闻资讯 /news

混凝土搅拌机的操作要符合相关内容才合适

来源:http://www.zkhntjbc.com/ 日期:2022-05-09
概述:  事实上任何一个机器设备在使用之前都要求操作人员按照相关内容来进行操作,这样做自然是为了保障操作人员的安全以及机器设备的正常运行
  事实上任何一个机器设备在使用之前都要求操作人员按照相关内容来进行操作,这样做自然是为了保障操作人员的安全以及机器设备的正常运行,混凝土搅拌机也不例外,那么它的操作要符合哪些相关内容才合适呢?
  In fact, any machine equipment before use requires the operator to operate in accordance with the relevant content, so it is natural to ensure the safety of the operator and the normal operation of the machine and equipment, the concrete mixer is no exception, so its operation should conform to the relevant content is appropriate?
  在使用前应进行一次空运转试机,在试机前应先检查混凝土搅拌机全部连接件的坚固程度,减速器内的润滑油油量和电器设备的完整性然后闭合总开关,通入电源,进行空运转试机。
  Before use, an empty operation test machine should be carried out. Before the test machine, it should first check the firmness of all connecting parts of the concrete mixer, the amount of lubricating oil oil in the reducer and the integrity of electrical equipment. Then close the total switch, access to the power supply, and carry out the empty operation test machine.
  空运转试机试验。在未发现不正常的响声、轴承档发高热、减速器温度直升等不良现象的情况下,才可使混凝土搅拌机投入生产。在运转中如需铲刮机内桶壁物料,应用竹木器工具,切不可用手,以免造成伤手事故。
  Air running test machine test. The concrete mixer can be put into production only when abnormal sound, high heat of bearing file and temperature helicopter of reducer are not found. In operation, if you need to shovel and scrape the material of the barrel wall of the machine, use bamboo tools, do not use hands, so as not to cause hand injuries.
  在使用中如发现机器震动异常或发出不正常怪声,应立即停掉混凝土搅拌机进行全面检查。
  If any abnormal vibration or abnormal sound is found during use, the concrete mixer should be stopped immediately for comprehensive inspection.
  使用负荷不要过大,一般以电动机的负荷来测定,用380V电动机在搅拌塑料时的重载电流,以不超过6安培为正常,如超过负荷应立即减少搅拌容量。
  The use load should not be too large, generally measured by the load of the motor, the heavy current of the 380V motor when mixing plastic is not more than 6 amperes as normal, such as exceeding the load should immediately reduce the mixing capacity.
  搅拌螺杆两端轴封应保持清洁,以免造成塑料发黑、变质,大搅拌桶体两端外档留有方孔,应通畅,切勿使混凝土搅拌机之堵塞,以免起反压力作用,使污物渗入轴心,使大桶内物料发黑、变质。
  Mixing screw at both ends of the shaft seal should be kept clean, so as not to cause plastic black, deterioration, large mixing barrel body at both ends of the file left square hole, should be unblocked, do not make the concrete mixer blocked, so as not to backpressure effect, so that the dirt into the shaft, so that the barrel material black, deterioration.
  管理人员必须熟悉混凝土搅拌机的技术性能、内部构造、控制结构及使用原理。运转期间不得离开工作地点,防止发生故障而损坏机件,以保证安全生产为前提。
  Management personnel must be familiar with the technical performance, internal structure, control structure and operating principle of concrete mixer. During operation, do not leave the working place to prevent failure and damage to the parts, in order to ensure safe production as the premise.
  打开电源,打开混色机盖子,用手按住安全保护开关,然后按下绿色启动开关,注意留意电机转向(顺时针旋转),如果方向反了,请按下红色开关停机并关闭电源,调换任意两根火线位置接线便可。
  Turn on the power, open the cover of the color mixer, press the safety switch with your hand, then press the green start switch, pay attention to the motor turning (clockwise rotation), if the direction is opposite, please press the red switch to stop and turn off the power, exchange any two live wire position wiring.
  确认混凝土搅拌机电机转向正确之后便可正常投入生产,请根据不同物料所需混色时间设定好时间后(定时器0~30分钟可调)进行生产使用。
  After confirming that the motor of concrete mixer turns correctly, it can be put into production normally. Please set the time according to the mixing time required by different materials (timer can be adjusted from 0 to 30 minutes) for production and use.
  混凝土搅拌机的操作要符合相关内容才合适的问题就讲解到这里了,如果您有纠结的内容可以来网站www.zkhntjbc.com看看相关咨询,然后寻求专业人员的帮助。
  The operation of concrete mixer should conform to the relevant content. The problem is explained here. If you have tangled content, you can come to the website www.zkhntjbc.com to see the relevant consultation, and then seek professional help.

截屏,微信识别二维码