混凝土搅拌机在进行运输重载混凝土的时候要求安装得当，才不会出现问题，而且之后要进行试运转，那么你知道它是如何进行安装以及后面的重载试运转的吗？下面小编为您分析分析。、

When transporting heavy-duty concrete, the concrete mixer is required to be installed properly so that there will be no problems, and then it will be tested. Do you know how it is installed and the subsequent heavy-duty test run? The following is a brief analysis for you

搅拌机的安装注意事项如下：

The installation precautions of mixer are as follows:

1、传动机构、工作装置、离合器、制动器，均应紧固，灵活可靠，防护罩齐全。

1. The transmission mechanism, working device, clutch and brake shall be fastened, flexible and reliable, and the protective cover shall be complete.

2、应设防雨棚，机械周围无泥水，干净整洁，各种牌示齐全。

2. Rainproof sheds should be set up, and there should be no muddy water around the machinery, which should be clean and tidy, and all kinds of signs should be complete.

3、应安装在牢固的台座上，若长期使用，应埋设地脚螺栓，若短期使用，应在机下铺设木枕并找平放稳。

3. It should be installed on a firm pedestal. If it is used for a long time, anchor bolts should be buried. If it is used for a short time, wooden pillows should be laid under the machine and leveled and placed stably.

4、钢丝绳不得有锈蚀、断丝、压扁等报废情况。

4. The steel wire rope shall be free of rust, broken wire, flattening and other scrapping conditions.

5、应安装在平坦坚硬的地坪上，用木方或支撑架架牢，并保持水平，不准以轮胎代替支撑，使用时间较长的（一般超过3个月的）应将轮胎卸下妥善保管，轮轴端部应做好清洁和防锈工作。

5. It should be installed on a flat and hard floor, firmly supported by timbers or support frames, and kept horizontal. It is not allowed to replace the support with tires. The tires that have been used for a long time (generally more than 3 months) should be removed and kept properly. The ends of the axles should be cleaned and rustproof.

6、应设置“一机一闸一漏一箱”漏电保护器参数为30MA×0.1S，电机绝缘电阻值应大于0.5MΩ；保护零线不少于两处，操作台仪表、指示信号准确可靠。

6. The parameter of "one machine, one switch, one leakage and one box" leakage protector should be set as 30mA × 0.1s, the insulation resistance of the motor should be greater than 0.5m Ω; There are at least two protection zero lines, and the instruments and indicating signals on the console are accurate and reliable.

7、机体上保险挂钩，料斗上吊耳应完好，当料斗升起时，应挂上保险钩。

7. The safety hook on the machine body and the lifting lug on the hopper should be intact. When the hopper is raised, the safety hook should be hung.

搅拌机如何重载试运转？

How to test run the mixer with heavy load?

1、按所需混凝土配比确定供水量，并调节时间继电器到相应的给水时间。

1. Determine the water supply according to the required concrete proportion, and adjust the time relay to the corresponding water supply time.

2、启动搅拌电动机运转。

2. Start the mixing motor for operation.

3、关闭卸料门，在料斗内加入所需的混合料后，提升料斗，料斗应运行平稳并能自如停止在轨道的任意位置，若有打滑现象，应先将料斗放入坑底，然后调整制动电机上的大螺母。料斗提升正常，制动可靠后，向搅拌罐内投料，同时启动水泵向搅拌罐内供水。

3. Close the discharge door, add the required mixture into the hopper, and then lift the hopper. The hopper should run smoothly and stop at any position of the track freely. If there is slip, put the hopper into the pit bottom first, and then adjust the big nut on the brake motor. After the hopper is lifted normally and the braking is reliable, feed into the mixing tank, and start the water pump to supply water to the mixing tank at the same time.

4、搅拌25-35秒后，启动卸料门卸料。

4. After 25-35 seconds of mixing, start the unloading door to unload.

5、在上述各项试运转过程中，如发现不正常情况，应立即停机检查，排除故障，然后再次试验，直到正常为止。

5. In the process of the above test run, if any abnormal condition is found, stop the machine immediately for inspection, eliminate the fault, and then test again until it is normal.

大家在驾驶混凝土搅拌机的时候一定要注意上面的事项，否则就会使车辆的使用寿命缩短，还有就是在每天使用完了之后要对车辆及逆行清理，不让混凝土粘结在上面。

When driving the concrete mixer, you must pay attention to the above matters, otherwise the service life of the vehicle will be shortened. In addition, after using it every day, you should clean the vehicle and retrograde to prevent the concrete from sticking to it.

以上就是问题解答的相关内容了，希望能够帮助到大家，如对这一问题还存在任何疑问，都欢迎关注我们网站http://www.zkhntjbc.com并咨询我们的工作人员，将竭诚为您服务。

The above is the relevant content of the question answer. I hope it can help you. If you still have any questions about this problem, you are welcome to follow our website http://www.zkhntjbc.com And consult our staff, will serve you wholeheartedly.